李锦,谢如鹤.冷藏车开门状态升温影响因素分析[J].农业机械学报,2014,45(6):254-259.
Li Jin,Xie Ruhe.Influence Factors of Air-temperature Increasing within Refrigerated Trucks during Door-opening State[J].Transactions of the Chinese Society for Agricultural Machinery,2014,45(6):254-259.
摘要点击次数: 3165
全文下载次数: 1380
冷藏车开门状态升温影响因素分析   [下载全文]
Influence Factors of Air-temperature Increasing within Refrigerated Trucks during Door-opening State   [Download Pdf][in English]
投稿时间:2013-07-13  
DOI:10.6041/j.issn.1000-1298.2014.06.039
中文关键词:  冷藏车  开门状态  升温  热质交换  影响因素
基金项目:国家自然科学基金资助项目(51008087、71172077)、广东省科技计划资助项目(2012B091100199)和韶关市科技计划资助项目(2011CX/K14)
作者单位
李锦 韶关学院 
谢如鹤 广州大学 
中文摘要:基于动态热平衡理论,建立了冷藏车开门状态厢内温度数学模型,并进行相应的试验验证,分析相关参数对车厢内温度的影响。研究结果表明:当制冷机组开启或关闭并打开车门6min,车厢内初始温度为0℃时,前者比后者升温仅低0.3℃,车厢内初始温度为-15℃时,前者比后者升温仅低0.7℃。当车厢内初始温度为0℃,蒸发器出风口风速分别为4m/s与2m/s、或者当隔热材料导热系数分别为0.05 W/(m·K)与0.033 W/(m·K)时,冷藏车开门6min后前者比后者温度升高均要低约0.2℃。此外,车厢内外的温差越大、车门开启越大、车厢体积越小,车厢内的温度升高也相应的越大;车厢外有、无风,或者风向不同,开门状态车厢内的升温快慢也不同。
Li Jin  Xie Ruhe
Shaoguan University;Guangzhou University
Key Words:Refrigerated trucks  During door-opening status  Temperature increasing  Heat and mass transfer  Influence factors
Abstract:The drastic changes of interior air-temperature and humidity induced by intense heat-mass exchange between inside and outside make the quality of perishable food difficult to guarantee while the door of the refrigerated truck is opened in the process of refrigerated transport. Aiming above problems, a mathematical model of interior temperature of refrigerator truck under the open-door state was established based on the theory of dynamic heat balance, and testified correspondingly through the analysis of influence of parameters on temperature. The test results showed that, when the refrigeration system turned on or off, and the door was opened in the 6min, and the initial temperature of the compartment was 0℃, the former temperature was 0.3℃ lower than the latter temperature. Similarly the former temperature was 0.7℃ lower than the latter temperature, when the refrigeration system turned on or off, and the door was opened in the 6 min, and the initial temperature of the compartment was -15℃. The former temperature was all 0.2℃ lower than the latter temperature, when comparing the speed of the evaporator outlet velocity was 4m/s and 2m /s, or the thermal conductivity of insulating materials was 0.05W/(m·K) and 0.033W/(m·K), and the door was opened in the 6min, and the initial temperature of the compartment was 0℃. Besides, the air-temperature increased more correspondingly inside refrigerated compartment in the situation of big temperature difference between interior and exterior and wider door-opening. Lastly, the interior heating rate was different according to the wind and wind direction outside of refrigerator carriage with the door opened. 

Transactions of the Chinese Society for Agriculture Machinery (CSAM), in charged of China Association for Science and Technology (CAST), sponsored by CSAM and Chinese Academy of Agricultural Mechanization Science(CAAMS), started publication in 1957. It is the earliest interdisciplinary journal in Chinese which combines agricultural and engineering. It always closely grasps the development direction of agriculture engineering disciplines and the published papers represent the highest academic level of agriculture engineering in China. Currently, nearly 8,000 papers have been already published. There are around 3,000 papers contributed to the journal each year, but only around 600 of them will be accepted. Transactions of CSAM focuses on a wide range of agricultural machinery, irrigation, electronics, robotics, agro-products engineering, biological energy, agricultural structures and environment and more. Subjects in Transactions of the CSAM have been embodied by many internationally well-known index systems, such as: EI Compendex, CA, CSA, etc.

   下载PDF阅读器