曹成茂,王安民,秦 宽,孙 燕,周 敏.一器多行环槽推送式排种器设计与试验[J].农业机械学报,2014,45(4):128-134.
Cao Chengmao,Wang Anmin,Qin Kuan,Sun Yan,Zhou Min.Multi-line Metering Device with Ring Groove Push Movement[J].Transactions of the Chinese Society for Agricultural Machinery,2014,45(4):128-134.
摘要点击次数: 3524
全文下载次数: 1330
一器多行环槽推送式排种器设计与试验   [下载全文]
Multi-line Metering Device with Ring Groove Push Movement   [Download Pdf][in English]
投稿时间:2013-11-15  
DOI:10.6041/j.issn.1000-1298.2014.04.020
中文关键词:  排种器 条播 环槽推送式 一器多行
基金项目:“十二五”国家科技支撑计划资助项目(2012BAD14B13)和安徽省农业机械管理局富民工程科技攻关资助项目(2012-1167)
作者单位
曹成茂 安徽农业大学 
王安民 安徽农业大学 
秦 宽 安徽农业大学 
孙 燕 安徽农业大学 
周 敏 安徽农业大学 
中文摘要:设计了一种适用于稻麦等小粒农作物条播的一器多行环槽推送式排种器,分析了排种器的工作原理和种子在出种口的受力情况,确定了排种盘的理论最大转速。以烟农19号小麦为试验对象,研究了单行种子排量、单行排量均匀性变异系数、各行排量一致性变异系数、总排量稳定性变异系数和破损率与排种盘转速的关系。试验表明,单行种子排量随排种盘转速的增大几乎呈线性增加关系。单行排量均匀性变异系数、各行排量一致性变异系数和总排量稳定性变异系数都随排种盘转速的增加呈现先减后增的趋势,并在转速为2.5r/min时最小,分别为28.5%、1.33%和0.51%。种子的破损率随着转速的增加而增加,在转速高于2.5r/min时,破损率增加较为明显。
Cao Chengmao  Wang Anmin  Qin Kuan  Sun Yan  Zhou Min
Anhui Agricultural University;Anhui Agricultural University;Anhui Agricultural University;Anhui Agricultural University;Anhui Agricultural University
Key Words:Seed-metering device Drill seeding Ring groove push type One-machine-multi-line
Abstract:A multi-line metering device was designed for drill seeding of wheat and rice with ring groove push movement. Working principle of the multi line metering device and force on dropping seed were analyzed, and the theoretical maximum speed of the metering plate was investigated. The Yannong-19 wheat was taken as the testing object, and the relationship among several parameters was studied, which were rotation speed with single-line delivery capacity, coefficient of variation of single-line flow rate, coefficient of variation of flow rate among all lines, coefficient of variation of total flow rate and damage rate through the captive test of seeding device. The experimental results showed that a linear increase was observed with increasing rotation speed. Coefficient of variation of single-line flow rate, flow rate among all lines and total flow rate firstly increased and then descended with increasing rotation speed, and the lowest coefficient of variation (28.5%,1.33% and 0.51%) were observed at 2.5r/min rotation speed. The damage rate increased with the increasing rotation speed, and increased obviously when rotation speed was higher than 2.5r/min.

Transactions of the Chinese Society for Agriculture Machinery (CSAM), in charged of China Association for Science and Technology (CAST), sponsored by CSAM and Chinese Academy of Agricultural Mechanization Science(CAAMS), started publication in 1957. It is the earliest interdisciplinary journal in Chinese which combines agricultural and engineering. It always closely grasps the development direction of agriculture engineering disciplines and the published papers represent the highest academic level of agriculture engineering in China. Currently, nearly 8,000 papers have been already published. There are around 3,000 papers contributed to the journal each year, but only around 600 of them will be accepted. Transactions of CSAM focuses on a wide range of agricultural machinery, irrigation, electronics, robotics, agro-products engineering, biological energy, agricultural structures and environment and more. Subjects in Transactions of the CSAM have been embodied by many internationally well-known index systems, such as: EI Compendex, CA, CSA, etc.

   下载PDF阅读器