王峰,严潇南,杨海真.鸡粪厌氧发酵沼液达标处理工艺研究[J].农业机械学报,2012,43(5):84-90.
Wang Feng,Yan Xiaonan,Yang Haizhen.Treatment Process of Anaerobically Digested Effluent of Chicken Manure for Meeting the Discharging Standard[J].Transactions of the Chinese Society for Agricultural Machinery,2012,43(5):84-90.
摘要点击次数: 4383
全文下载次数: 2090
鸡粪厌氧发酵沼液达标处理工艺研究   [下载全文]
Treatment Process of Anaerobically Digested Effluent of Chicken Manure for Meeting the Discharging Standard   [Download Pdf][in English]
  
DOI:10.6041/j.issn.1000-1298.2012.05.015
中文关键词:  鸡粪  沼液  厌氧发酵  达标处理
基金项目:“十一五”国家科技支撑计划资助项目 (2009BAC57B01、2008BADC4B05)
作者单位
王峰 同济大学 
严潇南 同济大学 
杨海真 同济大学 
中文摘要:为解决鸡场沼气工程沼液后续处理问题,以某养鸡场沼气工程全混式发酵池出水沼液处理为例,研究鸡粪厌氧发酵沼液的达标处理工艺。从鸡粪厌氧发酵沼液的特点出发,采用生化法与物化法相结合工艺处理沼液,并考查了3种不同组合的工艺处理效果。先以小试试验确定工艺最佳运行参数,再中试运行考查工艺的处理效果。结果表明:采用鸟粪石—SBR—混凝工艺处理鸡粪厌氧发酵沼液,沼液CODCr由9200mg/L降至280mg/L,NH+4N由3200mg/L降至36mg/L,TP由270mg/L降至3.3mg/L,达到畜禽养殖业污染物排放标准(GB 18596—2001);对于鸡粪厌氧发酵沼液中NH+4N的去除,直接采用SBR处理,微生物会受到游离氨抑制,NH+4N去除率不足30%,生化处理前必须采用预处理降低NH+4N负荷;鸡粪厌氧发酵沼液生化性良好,但仍含有一定量难降解CODCr,采用生化处理结合物化工艺进行深度处理可以以较低成本实现达标排放。
Wang Feng  Yan Xiaonan  Yang Haizhen
Tongji University;Tongji University;Tongji University
Key Words:Chicken manure  Biogas slurry  Anaerobic fermentation  Up-to-standard treatment
Abstract:To solve subsequent treating problems of chicken farm biogas project slurry, a research was carried out on treatment processes of anaerobically digested effluent of chicken manure for meeting the discharging standard—a case study of treatment of CSTR fermentation tank effluent of a biogas project. Based on the characteristics of anaerobically digested effluent of chicken manure, bio-chemical treatment combined with physical-chemical process was used to treat the biogas slurry. In addition, effects of three different processes combination method were investigated. First, bench scale experiment was carried out to determine the optimal operation parameters, and then pilot scale devices were introduced to examine the effect of the process. Results showed when using struvite—SBR—coagulation process treating anaerobically digested effluent of chicken manure, CODCr decreased from 9200mg/L to 280mg/L, NH+4N decreased from 3200mg/L to 36mg/L, TP decreased from 270mg/L to 3.3mg/L, finally the effluent met the standard GB 18596—2001. To remove NH+4N in chicken manure slurry, pretreatment is essential. Because of inhibition of free ammonia to microorganism, NH+4N removal rate is less than 30% while using SBR directly treating chicken manure slurry. Biodegradability of anaerobically digested effluent of chicken manure is good, but the amount of refractory CODCr is considerable. Using bio-chemical treatment combined with physical-chemical advanced process can meet the discharging standard with lower cost.

Transactions of the Chinese Society for Agriculture Machinery (CSAM), in charged of China Association for Science and Technology (CAST), sponsored by CSAM and Chinese Academy of Agricultural Mechanization Science(CAAMS), started publication in 1957. It is the earliest interdisciplinary journal in Chinese which combines agricultural and engineering. It always closely grasps the development direction of agriculture engineering disciplines and the published papers represent the highest academic level of agriculture engineering in China. Currently, nearly 8,000 papers have been already published. There are around 3,000 papers contributed to the journal each year, but only around 600 of them will be accepted. Transactions of CSAM focuses on a wide range of agricultural machinery, irrigation, electronics, robotics, agro-products engineering, biological energy, agricultural structures and environment and more. Subjects in Transactions of the CSAM have been embodied by many internationally well-known index systems, such as: EI Compendex, CA, CSA, etc.

   下载PDF阅读器